Improving vitamin D content in pork meat by UVB biofortification.

Vitamin D deficiency is prevalent worldwide and identification of alternative food-based strategies are urgently warranted. In two studies, 12-week old crossbred pigs (Duroc x (Large White x Landrace)) were exposed daily to narrowband UVB radiation for ∼10 weeks or control (no UVB exposure) until slaughter. In Study 1 (n = 48), pigs were exposed to UVB for 2 min and in Study 2 (n = 20), this duration was tripled to 6 min. All pigs were fed the maximum permitted 2000 IU vitamin D3/kg feed. Loin meat was cooked prior to vitamin D LC-MS/MS analysis. In Study 1, pork loin vitamin D3 did not differ between groups. Study 2 provided longer UVB exposure time and resulted in significantly higher loin vitamin D3 (11.97 vs. 6.03 µg/kg), 25(OH)D3 (2.09 vs. 1.65 µg/kg) and total vitamin D activity (22.88 vs. 14.50 µg/kg) concentrations, compared to control (P < 0.05). Pigs remained healthy during both studies and developed no signs of erythema. Biofortification by UVB radiation provides an effective strategy to further safely increase the naturally occurring vitamin D content of pork loin, alongside feed supplementation.

Bioavailability of vitamin D biofortified pork meat: results of an acute human crossover study in healthy adults.

Vitamin D intakes are concerningly low. Food-based strategies are urgently warranted to increase vitamin D intakes and subsequently improve 25-hydroxyvitamin D (25(OH)D) concentrations. This acute randomised three-way crossover study investigated the efficacy of vitamin D biofortified pork derived from pigs exposed to UVB light to increase serum 25(OH)D3 concentrations, compared to a dose-matched vitamin D3 supplement and control pork in adults (n = 14). Blood samples were obtained at baseline and then 1.5, 3, 6, 9 and 24 h postprandially. There was a significant effect of time (p < 0.01) and a significant treatment*time interaction (p < 0.05). UV pork and supplement significantly increased within-group serum 25(OH)D3 concentrations over timepoints (p < 0.05) (max. change 0.9 nmol/L (2.2%) UV pork, 1.5 nmol/L (3.5%) supplement, 0.7 nmol/L (1.9%) control). Vitamin D biofortified pork modestly increased 25(OH)D3 concentrations and produced a similar response pattern as a dose-matched vitamin D supplement, but biofortification protocols should be further optimised to ensure differentiation from standard pork.

Impact of cooking on vitamin D3 and 25(OH)D3 content of pork products.

Little is known regarding the impact of cooking on vitamin D content in pork, despite meat being a major contributor to vitamin D intakes. This paper investigated the effect of household cooking (pan-fry/roast/grill/sous-vide/sauté), on the vitamin D3 and 25-hydroxyvitamin D3 (25(OH)D3) concentration/retention in pork loin, mince and sausages. We hypothesised that vitamin D concentrations would be higher in cooked vs raw pork, and retention would differ between products. Cooking significantly increased vitamin D3 (+49 %) and 25(OH)D3 (+33 %) concentrations. All cooked loin vitamin D3 concentrations were significantly lower than mince/sausage. Vitamin D3 retention was > 100 % for all samples (102-135 %), except sauté mince (99 %) which still did not differ significantly from 100 % retention. Sous-vide cooking resulted in the highest vitamin D3 retention (135 %). Likely owing to water/fat loss, household cooking of pork results in favourable retention of vitamin D3 and 25(OH)D3. The type of pork product has greater influence than cooking method.